高鐵輕軌地鐵地道專用電纜WZR-DZY22

一、履行規范standard：
企業規范Enterprise’s standard
二．適用范圍Applications：
    該電纜適用于地鐵．地道．車站等相對密閉人員會集．有很高的阻燃要求．且特別要求在焚燒時不出產濃煙，有毒害效果的鹵酸氣體及禁止焚燒發生“二次災禍”的嚴苛環境下運用。特別適用于地道沿線及配電柜與地鐵之間的敷設。
  Suitable for subway．tunnel，station etc with crowded people wherever requires higher flame-retardant，less amount of smoke and poisonous halogen gas when burning and not cause“the second disaster”．Especially suitable for installation and laid along tunnel line．power cabinet and rai1way．
三、運用特性Properties：
    1．產品類型：WZR-DZY(詳細規范拜見附表)
  Model：WZR-DZY(detail is see the attached table)
  注：①WZR(A、B)-DZY WZR(A、B)-DZY均與上類型等效。
      ②阻燃等級：WZRA--為A類低煙無鹵阻燃
                  WZRB--為B類低煙無鹵阻燃
                  WZR---為c類低煙無鹵阻燃
  2．額外電壓750V，1500V
  Rated voltage：750V．1500V
  3．標稱截面O.5-400mm2
  Nominal cross section area：O.5-400mm2
  4．導體長時間作業溫度70℃，短路過載溫度可到達130℃(5s)
  Permissible long-term working temperature is 70℃．Max．working temperature of the conductors in short- circuit is 130℃．(5S)
  5．電纜最小答應曲折半徑不超越電纜直徑的15倍。
    Allowed Min．bending radius are not more than 1 5 times 0f cable O．D．
  6．電絕緣功能，物理機械功能優異
    Possessing good electrical insulation performance，physical mechanical properties．
7．電纜阻燃功能到達GB／T18380．3-2001電纜成束焚燒實驗A、B、C類(IEC332-3)的要求
Flame-residence comforts to the requirement of GB／T1 8380．3-2001(IEC332-3)
8、低煙特性：滿意GB／T17650-1998，GB／T17651—1998的要求 
Low-smoke property comforts to GB／T17650-1 998．GB／T17651—1 9989．
9、無鹵特性：(1)導電率≤10  μs／mm
               (2)PH值≥4．3
 Non-halogen property：(1)Conductivity≤10 μs／ram
                       (2)PH≥4．3
10、煙氣毒性契合GAl32準安全級的要求。
  Smoke poisonous conform to GAl32．
空氣敷設長時間接連負荷載流量單位：A
Continue loading current of cable laid in air

注：環境溫度為40：C Note：environment temperature is 40℃
地鐵地道專用電纜結構參數表Cable construction

編制闡明Directions：
    1．低煙無鹵阻燃聚烯烴絕緣地鐵地道專用電纜接連負載電流是根據IEC-287電纜載流量核算規范進行核算的，并經過批改確認。
    Continuous loading current of cable is calculated per IEC-287
    2．此地鐵地道專用電纜的長時間作業溫度不超越70℃。
    Long-term working temperature is not more than 70℃．
    3．布線方法分為觸摸與非觸摸兩種，其中非觸摸指電纜間的彼此間隔大于二倍的電纜外徑．觸摸即指電纜彼此靠在一同或彼此距離小于二倍的電纜外徑。
  Laid method：contact and non contact．Non contact laid means the distance between the laying cable is more than 2 times of cable O．D．Contact laid means the distance between the laying cable is not more than 2 times of cable O．D．
    4．周圍環境溫度以40℃作為基準溫度。
    Environment temperature is supposed 40℃ as basic temperature
環境溫度改變批改系數表
The revised coefficient of the environmental temperature change

電纜敷設于塑料槽中載流量批改系數表 
The revised coefficient of the cable loading current lay in plastic flume

注：K系指在塑料槽中有負荷電纜根數與總的電纜根數之比(負荷電纜我指通是流發熱電纜，信號線在外)。
                                                    Note．  k=   Loading current cables

                                                                      Total number of the cables
(Loading current cables means cables that generating heat when working excet for signal line)
電纜穿管敷時載流量批改系數表
 The revised coefficient of the cable loading current lay in tube

注：
1．穿管根數指有負荷發熱的電纜根數。
2．穿管線的體積不超越管體積的40％。
3．當管并排敷設時乘0．95批改系數。
Note：
1) The number of the cable in tube means the number of the cables which generates heat while loading.
2)The cable’s volume is not more than 40％ of the rube’s volume．
3)When cable laid stand by stand，multiply the revised coefficient with 0.95